Brightr / Inzone Commissioning Report

• Site conducted

  Select

• Conducted on

  Date

• Prepared by

• Location
  Address

Site Details

• OPP#

  Yes

  No

  N/A

• Work Order #

• Email Address:

• Install Team Names:

• Site Address:

• Install Date:

  Date

• Scheduled Time Allowed

  Date

• Time Started

  Date

• Time Completed:

  Date

• Did you have to leave site for any reason?

  Yes

  No

  N/A

• Reason for leaving site:

Outdoor Unit

• Outdoor Unit Secure? (Not likely to fall over)

  Yes

  No

  N/A

• Any vibration or noise disturbance to owners or adjacent properties?

  Yes

  No

  N/A

• If yes, what remedial action was taken?

• Area around the unit clear (no blockage to air supply routes)?

  Yes

  No

  N/A

• Servicing access provided?

  Yes

  No

  N/A

• Duct neat, secure, sealing, flashing, waterproofing complete?

  Yes

  No

  N/A

• Service covers replaced?

  Yes

  No

  N/A

• Manufacturers installer checklists viewed and complied with?

  Yes

  No

  N/A

• Unit clearly labelled?

  Yes

  No

  N/A

• Photo - ODU reflecting position against wall with regard to gas, pathway, deck. Include Isolator

  Media

• Photo - Paircoil connections to ODU

  Media

• Photo - Draincoil route to ODU, or directed away from ODU

  Media

• Photo - Electrical connections at isolator

  Media

• Photo - Fixing of unit to polyblocks, polyblocks to base - front and rear

  Media

• Photo - Electrical Connections in ODU

  Media

• Photo - Ductwork showing sealant at penetration and top cap

  Media

• Photo - Clearance above ODU (with tape measure)

  Media

• Photo - Clearance behind ODU with tape measure

  Media

• Photo - Clearance left of ODU (with tape measure)

  Media

• Photo - Clearance right of ODU with tape measure

  Media

• Photo - Manufacturers label including model number and serial number

  Media

Indoor Unit

• Indoor Unit Secure? (No vibration)

  Yes

  No

  N/A

• If no, what remedial action was taken?

• Indoor neat and tidy (No visible pipework, no gaps in duct work if used)?

  Yes

  No

  N/A

• Manufacturers installer checklists viewed and complied with?

  Yes

  No

  N/A

• Test run completed?

  Yes

  No

  N/A

• Photo - IDU reflecting position against wall with regard space and positioning (windows and doors)

  Media

• Photo - Paircoil connections behind IDU

  Media

• Photo - Draincoil route from IDU if no condensate pump used

  Media

• Photo - Electrical Connections in IDU

  Media

• Photo - Pipework connections from condensate pump if used

  Media

• Photo - Filters installed?

  Media

• Photo - Electrical connections to condensate pump if used

  Media

• Photo - Clearance above IDU (with tape measure)

  Media

• Photo - Clearance below IDU with tape measure

  Media

• Photo - Clearance left of IDU (with tape measure)

  Media

• Photo - Clearance right of IDU with tape measure

  Media

• Photo - Manufacturers label including model number and serial number

  Media

Pipework

• Pipework sizing right for the unit

  Yes

  No

  N/A

• Pipework length appropriate (within chargeless limit)?

  Yes

  No

  N/A

• If not how many metres pipework added?

• Was gas added?

  Yes

  No

  N/A

• If Yes, How Much?

• Pressure/Leak test completed?

  Yes

  No

  N/A

• System Evacuated?

  Yes

  No

  N/A

• Vacuum achieved and held?

  Yes

  No

  N/A

• How Long?

• Manufacturers pipework installer checklists viewed and complied with?

  Yes

  No

  N/A

Drainage

• IDU Drain coil correctly installed?

  Yes

  No

  N/A

• IDU Drainage tested by pouring water into tray?

  Yes

  No

  N/A

• ODU drainage direct away from pathways and deck appropriately?

  Yes

  No

  N/A

Electrical

• Unit connected to a dedicated circuit, hard wired back to the main board?

  Yes

  No

  N/A

• If connected to an existing circuit, does the circuit have sufficient spare capacity?

  Yes

  No

  N/A

• Appropriate circuit protection installed and labeled?

  Yes

  No

  N/A

• Isolator installed near ODU?

  Yes

  No

  N/A

• Have the electrical tests been completed and entered onto the test sheet, and did the unit pass?

  Yes

  No

  N/A

• Is the energy rating label on the unit or easily viewed?

  Yes

  No

  N/A

• COC competed and issued?

  Yes

  No

  N/A

• Has a copy of the electrical COC been given to the owner?

  Yes

  No

  N/A

• Photo of Switchboard showing protective device and labelling

  Media

• Photo of Test results

  Media

• Photo of COC

  Media

Handover

• Has the operation of the system been explained to the owner?

  Yes

  No

  N/A

• Has the owner been advised of maintenance and servicing requirements?

  Yes

  No

  N/A

• Does owner have the operating manual?

  Yes

  No

  N/A

• Does owner have a copy of the warranty?

  Yes

  No

  N/A

General

• Were there any issues experienced with the installation?

  Yes

  No

  N/A

• Were there any Scope Issues?

  Yes

  No

  N/A

• Were there any Electrical Issues?

  Yes

  No

  N/A

• Were there any Product Issues?

  Yes

  No

  N/A

• Were there any Installation Issues?

  Yes

  No

  N/A

• Who have you informed about these issues?

• Was there a variation to the work order?

  Yes

  No

  N/A

• If Yes, Did the customer sign the Variation?

  Yes

  No

  N/A

Uploads

• Commissioning report ready to submit?

  Yes

  No

  N/A

• Variation ready to submit?

  Yes

  No

  N/A

• Photographs, commissioning report and variation ready for upload, or to be emailed?

  Yes

  No

  N/A