WAFarmers Farm Pre Season Tractor Inspection

• Farm Name

• Inspection Conducted on

  Date
• Location
  Address

• Conducted by

  Sign

• References - Work Health and Safety Act 2020, Work Health and Safety (General) Regulations 2022, Worksafe WA guides & Publications, Farmsafe Australia, Australian Centre for Agriculture Health and Safety, University of Sydney and other relevant documentation available across Australia.

• Disclaimer - The information provided in this document is not a service as provided by Section 26A Work Health and Safety Act 2020 and can only assist you in the most general way. This document does not replace your statutory requirement or legislation obligations under any relevant state and territory legislation that you are responsible for. WAFarmers or Preplan Pty Ltd is not liable in any form resulting from any action taken or reliance made by you on the information or material contained in this document which is of a general nature. Before relying on the material, users should carefully make their own assessment as to its accuracy, currency, completeness and relevance for their purposes, and should obtain own independent legal advice relevant to their particular circumstances. Notwithstanding anything contained therein, WAFarmers or Preplan Pty Ltd will not except or be liable in any form for any loss or other consequences (whether or not due to the negligence of the consultants, their servants or agents) arising out of the services rendered by the consultants. This document is copyright© to WAFarmers and Preplan Pty Ltd in all forms and aspects.

Before you Start your checks

Are you competent to operate/been instructed on the correct use of this tractor?

• Yes

  No

  N/A

• Do not proceed - contact your supervisor and await instruction.

Ensure vehicle has all its power sources isolated

• Turn off the isolator, remove the key from the ignition, ensure all hand/mechanical brakes are applied

• Yes

  No

  N/A

Check engine oil level

• Park on a flat surface, check engine oil before starting engine or 5 minutes after engine has stopped

  Level is within limits

  Needs topping up

Check Radiator expansion tank

• Check to see that the coolant level is between the FULL and LOW marks of recovery tank. When coolant level drops due to evaporation, add correct inhibitor/rain water only up to the FULL level

  Pass

  Fail

  N/A

Clean grill and radiator screen

• To clean detach screen and remove foreign matter

  Level is within limits

  Needs topping up

Check air cleaner dust indicator

• Check dust indicator on air cleaner body, if red signal visible, clean immediately

  Level is within limits

  Needs topping up

Check brake and clutch pedal

• Inspect brake and clutch pedals for free travel and smooth operation

  Level is within limits

  Needs topping up

Check indicators, gauges, and meter

• Inspect lights for broken bulbs or lenses

  Level is within limits

  Needs topping up

Check seat belts

• Check for worn or frayed belts, and that catches are clear of dust

  Level is within limits

  Needs topping up

Refuel

• Turn key to ON check fuel gauge. Fill when tank shows 1/4 or less. Refuel with diesels if required, when you start refueling an intermittent buzzer sounds, stop refueling when buzzer goes continuos.

  Level is within limits

  Needs topping up

Warning and caution labels

• Check that all labels are still visible

  Level is within limits

  Needs topping up

Tyre pressure

• Tyre pressure FRONT 140 Kaplan (1.4kgf/cm2, 20 psi) REAR (1.4kgf/cm2, 20 psi). If utilizing front end loader, ensure front tyres are set to maximum inflation

  Level is within limits

  Needs topping up

• Photos if required from inspection

  Media

Sign off

• Select date

  Date

• Add signature

  Sign