Job Site Safety Inspection

• Job Site

• Prepared by

• Location
  Address

• Personnel

Site Information

• Sign-In Sheet

• Start Time

• Lunch time starts and ends at what times?

• Rollup Time

Crews on site

• Number of framers working including the supervisor

• Supervisor on site

• Number of finishers working including the supervisor

• Supervisor on site

• Number of EIFS working including the supervisor

• Supervisor on site

• Number of scaffold builders working including supervisor

• Supervisor on site

General

• Emergency telephone numbers posted?

  Yes

  No

  N/A

• Is there a competent person, someone capable of identifying existing and predicable hazards which are unsanitary, hazardous or dangerous, and who has authorization to take prompt corrective measures to eliminate them, on site?

  Yes

  No

  N/A

• Are first aid supplies adequate?

  Yes

  No

  N/A

• Are weekly safety meetings being held and safety sheets being signed?

  Yes

  No

  N/A

• SDS on site and accessible to all employees?

  Yes

  No

  N/A

Housekeeping

• Housekeeping: aisles clean, scrap removed, work areas clean and free of dangerous waste and material.

  Yes

  No

  N/A

• Select from range

• Work areas have appropriate lighting.

  Yes

  No

  N/A

• Adequate supply of water or water jugs, cups and trash containers?

  Yes

  No

  N/A

Personal Protective Equipment (PPE)

• Head,eye, face, and hand protection worn?

  Yes

  No

  N/A

• Respiratory protection worn when needed/required?

  Yes

  No

  N/A

• Safety harnesses, lifelines and lanyard worn when needed/required?

  Yes

  No

  N/A

Fire Protection & Prevention

• Are portable fire extinguishers provided in adequate number and type and in readily accessible locations?

  Yes

  No

  N/A

• All employees or subcontractors know the location of the fire extinguishers.

  Yes

  No

  N/A

• Portable heaters are being used in accordance with specifications.

  Yes

  No

  N/A

• Flammable & combustible liquids in approved containers only?

  Yes

  No

  N/A

Electrical

• All equipment is either grounded or double insulated.

  Yes

  No

  N/A

• GFCI receptacle used including when using permanent power?

  Yes

  No

  N/A

• Temporary lights are equipped with guards to prevent accidental contact with bulb.

  Yes

  No

  N/A

• Extension cords are not frayed, cut, nicked and are in good repair with intact ground pin.

  Yes

  No

  N/A

Tools

• All tools are in good working order.

  Yes

  No

  N/A

• Tool cords are free of cuts or abrasions and in good repair.

  Yes

  No

  N/A

• Proper tool being used for job?

  Yes

  No

  N/A

• Tools are being used properly?

  Yes

  No

  N/A

• Guards in place?

  Yes

  No

  N/A

• Powder actuated tools are unloaded when not in use.

  Yes

  No

  N/A

Ladders

• Ladders are in good condition with all appropriate labels and have slip resistant feet and away from electrical exposures.

  Yes

  No

  N/A

• Ladders properly secured to prevent slipping, sliding or falling?

  Yes

  No

  N/A

• Do straight ladders extend 36" above top of landing?

  Yes

  No

  N/A

• Stepladders fully open when in use; no standing on top two steps?

  Yes

  No

  N/A

Perry Scaffolds

• Constructed by a qualified person

  Yes

  No

  N/A

• Components are in good repair

  Yes

  No

  N/A

• Scaffold is set up on baseplates or casters

  Yes

  No

  N/A

• Baseplates are used in place of casters in stairway

  Yes

  No

  N/A

• All 4 wheels are locked

  Yes

  No

  N/A

• Stacked scaffolds has a set of outriggers with casters in use

  Yes

  No

  N/A

• Working surface is free of debris and material

  Yes

  No

  N/A

• All open sides and ends of the working platform more than 6' above ground are provided with guardrails

  Yes

  No

  N/A

Scaffolding

• Scaffolding is constructed by a qualified person

  Yes

  No

  N/A

• Scaffold equipment in good working order

  Yes

  No

  N/A

• Inspected by competent person daily before use?

  Yes

  No

  N/A

• Scaffolding was erected per the manufacturers instructions and will meet the guidelines outlined in OSHA standards

  Yes

  No

  N/A

• Footing and anchors are sound, rigid, and capable of carrying 4 times the maximum intended load without settling or displacement

  Yes

  No

  N/A

• The scaffold is set up on adequate flat baseplates on mudsills, screw jacks, etc.

  Yes

  No

  N/A

• All connections are pinned or fastened securely

  Yes

  No

  N/A

• All 4 wheel are locked

  Yes

  No

  N/A

• Scaffolding is properly supported on scaffold jacks and not on stacks of wood, boxes, bricks, blocks, barrels or any other unstable materials

  Yes

  No

  N/A

• Planks are certified scaffold planks or structural lumber

  Yes

  No

  N/A

• Planks overlap the end of the scaffold no less than 6" and no more than 12"

  Yes

  No

  N/A

• The working surface is fully planked

  Yes

  No

  N/A

• Planks are secured to prevent slipping

  Yes

  No

  N/A

• Less than a 1" gap between planks to prevent tools, etc., from falling through

  Yes

  No

  N/A

• Less than 14" between scaffold and working surface

  Yes

  No

  N/A

• Ladders are used to gain access to scaffold work platforms

  Yes

  No

  N/A

• Maximum spacing of rungs is 16 3/4

  Yes

  No

  N/A

• Scaffold is free of debris and material

  Yes

  No

  N/A

• The scaffold is tied off if it is more than four times the width of the base

  Yes

  No

  N/A

• All open sides and ends of the platforms more than 6' above ground are provided with top rails, midrails, and toebords

  Yes

  No

  N/A

• Top rails are between 39" to 45" high, midrails are midway between working platform and top rail

  Yes

  No

  N/A

• Guardrails are capable of withstanding 200lbs of force along the top rail

  Yes

  No

  N/A

• Gates or bars are used to enclose the top level

  Yes

  No

  N/A

• Scaffold is tied off every 30' horizontally and 26' vertically, or tied off if the height exceeds 4 times the width of the base

  Yes

  No

  N/A

• On suspended scaffolds, lifelines are attached to structure and a safety harness is used

  Yes

  No

  N/A

Fall Protection

• Floor opening covered/guardrails in place?

  Yes

  No

  N/A

• Open-sided floors/wall opening have guardrails?

  Yes

  No

  N/A

• Roof edge adequately guarded?

  Yes

  No

  N/A

• Leading edge protection & signage utilized where required?

  Yes

  No

  N/A

• 100% fall tie off for all heights above 6 ft with proper anchor points?

  Yes

  No

  N/A

• All horizontal lifeline systems engineered?

  Yes

  No

  N/A

Aerial and Scissor Lifts

• Are employees authorized?

  Yes

  No

  N/A

• Safety chains in place on scissors lifts?

  Yes

  No

  N/A

• Are daily lift inspection checklist being completed?

  Yes

  No

  N/A

• Are they clean and in good repair?

  Yes

  No

  N/A

Industrial Truck - Forklift

• Only those who are authorized to operate the forklift are permitted to do so.

  Yes

  No

  N/A

• Regular inspection and maintenance logs complete?

  Yes

  No

  N/A

• Lights, brakes, horn, back up alarm operative?

  Yes

  No

  N/A

• Seat belts being used?

  Yes

  No

  N/A

• Fire extinguisher installed?

  Yes

  No

  N/A

Quality Control

Framing

• Plumb and straight?

  Yes

  No

  N/A

• Door jams in?

  Yes

  No

  N/A

• No loose ends

  Yes

  No

  N/A

Drywall

• Clean and screwed off?

  Yes

  No

  N/A

• Tape ready?

  Yes

  No

  N/A

• Are control joints in?

  Yes

  No

  N/A

• No loose ends

  Yes

  No

  N/A

Finishing

• Walls are free of humps and bumps

  Yes

  No

  N/A

• Fire spray / caulk ok

  Yes

  No

  N/A

• Beads are straight, plumb and level

  Yes

  No

  N/A

• Clean up looks good

  Yes

  No

  N/A

• No loose ends

  Yes

  No

  N/A

Sheathing

• Complete

  Yes

  No

  N/A

• Screws are 8" in field and 6" around perimeter

  Yes

  No

  N/A

• No loose ends

  Yes

  No

  N/A

Weather Seal

• Complete

  Yes

  No

  N/A

• Does it look good?

  Yes

  No

  N/A

EIFS

• Is there back wrap at window openings & terminations?

  Yes

  No

  N/A

• Do V groves look straight & are corners tight?

  Yes

  No

  N/A

• Is flashing plumb & level?

  Yes

  No

  N/A

• There is not mesh visible

  Yes

  No

  N/A

• Is finish uniform?

  Yes

  No

  N/A

• Clean up looks good

  Yes

  No

  N/A

Sign Off

• Framing Supervisor Signature

  Sign

• Finish Supervisor Signature

  Sign

• EIFS Supervisor Signature

  Sign

• Scaffolding Supervisor Signature

  Sign

• Safety Representative Signature

  Sign