Marchetti Contructions Independence Report

• Site conducted
  Address

• Conducted on

  Date

• Prepared by

• Site Supervisor

• Type of Frame

  Pre - Fab

  Stick Build

• Type of Build

  Single Storey

  Double Storey

• Crew completing frame

• Inspect no.

  1st

  2nd - Double Check

• Site cleaned and spotless

  Yes

  No

  N/A

• No. wall OOP

• Materials need order

  Yes

  No

• OVERALL COMMENTS

• Job site is cleaned and spotless. Left over timber is stacked neatly in the garage. House was swept out and cleaned.

  Yes

  No

  N/A

• All rooms and doors locations, size has been marked out>

  Yes

  No

  N/A

SURVEYOR, PRIVATE FRAME REPORT

• Did the job pass

  Yes

  No

  N/A

• All private report items complete

  Yes

  No

  N/A

• Frame written up items complete

  Yes

  No

  N/A

• Other trade email items complete

  Yes

  No

  N/A

WINDOW INSTALL

• All opening are correct as pre-plans and All windows installed

  Yes

  No

• Windows/door frames are leveled and plumbed and packed correctly, the write way around

  Yes

  No

  N/A

• All window sashes/panels installed

  Yes

  No

  N/A

• All header windows gap less than 35mm and block correctly also greater than 10mm

  Yes

  No

  N/A

• SQ.set windows are flush with frames

  Yes

  No

  N/A

• Kitchen/Gallery windows at 920/940mm off floor, plumb, level (bottom & top), bottom sill at least 20mm lower to allow stones go through. Top windows level and countersink secure leveled

  Yes

  No

  N/A

• Stiffening board installed under Kitchen/Gallery windows (Valleyboards, floorboards block at 2 ends and 900 cents at middle

  Yes

  No

  N/A

• Window protection/rails in place.

  Yes

  No

  N/A

• Sliding doors are installed correctly with 3 screws and L brackets underneath

  Yes

  No

  N/A

• Flashings installed to sill section of timber windows and timber framed doors.

  Yes

  No

  N/A

• Big void window is level/plumb not bow at midde

  Yes

  No

  N/A

PRE - PLASTER ITEMS

• Voids from ground to first floor alignment

  Yes

  No

  N/A

• Wall plumb (+/- 4mm over 2.0m)

  Yes

  No

  N/A

• Flooring level (+/- 4mm over 2.0m, or 10mm in a room)

  Yes

  No

  N/A

• Sheet flooring nailed off and not squeaking.

  Yes

  No

  N/A

• Nails hit flat at internal ply braces

  Yes

  No

  N/A

• Top and bottom wall plates secure and straight/alignment

  Yes

  No

  N/A

• Walls Nog's installed correctly

  Yes

  No

  N/A

• Ceiling trimmer installed correctly

  Yes

  No

  N/A

• Change direction over joists at lower

  Yes

  No

  N/A

• Bulkheads level and installed (+/- 4mm over 2.0m) level.

  Yes

  No

  N/A

• Columns plumb and square with no twist.

  Yes

  No

  N/A

• Change of direction nog's installed at direction change of roof trusses and where required (all bay)

  Yes

  No

  N/A

• Man hold frame out

  Yes

  No

  N/A

• Garage perimeter nogs for roller doors and pack 2 sides at least 120mm wide

  Yes

  No

  N/A

• Alfresco battons/ ensure have 2 ends timbers to pick plasters

  Yes

  No

  N/A

HEBEL/ BRICK ITEMS

• Balcony frame out

  Yes

  No

  N/A

• All bolts cut off

  Yes

  No

  N/A

• Garage opening correctly

  Yes

  No

  N/A

• Drop porch/alfresco

  Yes

  No

  N/A

• Column frame out, studs to steel block out

  Yes

  No

  N/A

OTHER ITEMS

• Any other items

  Yes

  No

  N/A