VEHICLE HEALTH REPORT
-
Conducted on
-
Full name of the inspector
-
Prepared by
-
Location
CUSTOMER | VEHICLE DETAILS
-
Customer's Name
-
Make
-
Model
-
Cylinder Configuration (L4, V6 or V8)
-
Chassis Number (VIN)
-
Plate Number
Untitled Page
-
undefined
- Oil Pressure Warning Light
- Tire Pressure Warning Light
- Engine Temperature Warning Light
- Traction Control Alert Light
- Anti-lock Brake System Warning Light
- Engine Warning Light (Check Engine Light)
- Traction Control Malfunction Light
- Battery Alert Light
- Low Fuel Indicator Light
- Automatic Shift Lock or Engine Start Indicator Light
- Seat Belt Reminder Light
- Airbag Warning Light
- Security Indicator Light (Immobilizer)
- Brake Warning Light
- Washer Fluid Indicator Light
- Lane Departure Warning Light
- Transmission Temperature Warning Light
- Dynamic Stability Control
- Hill Descent Control
- Triangle Critical Warning?
- Exhaust Filter | DEF
PRE-INSPECTION REPAIRS
PRE-INSPECTION CHECKS
FLUIDS
-
Engine Oil/Filter Change and Chassis Lube
-
Coolant
- Oil Pressure Warning Light
- Tire Pressure Warning Light
- Engine Temperature Warning Light
- Traction Control Alert Light
- Anti-lock Brake System Warning Light
- Engine Warning Light (Check Engine Light)
- Traction Control Malfunction Light
- Battery Alert Light
- Low Fuel Indicator Light
- Automatic Shift Lock or Engine Start Indicator Light
- Seat Belt Reminder Light
- Airbag Warning Light
- Security Indicator Light (Immobilizer)
- Brake Warning Light
- Washer Fluid Indicator Light
- Lane Departure Warning Light
- Transmission Temperature Warning Light
- Dynamic Stability Control
- Hill Descent Control
- Triangle Critical Warning?
- Exhaust Filter | DEF
-
Brake Fluid
-
Automatic Transaxle/Transmission Fluid
-
Transfer Case Fluid
-
Drive Axle Fluid
-
Power Steering Fluid
-
Manual Transaxle/Transmission Hydraulic Clutch Fluid
-
Washer Fluid
ENGINE
-
Fluid Leaks Underneath and surroundings
-
Engine Air Filter
-
Hoses, Lines and Fittings
-
Belts
-
Wiring harness check for alteration
-
Oil in Air Cleaner Housing
-
Water, Sludge or Engine Coolant in Oil
-
Oil Pressure
-
Relative Cylinder Compression Test/Power Balance Readings(Check If Necessary)
-
Timing Belt
-
Engine Mounts
-
Inspect Turbocharger Air Cooler
-
Exhaust System Condition Noise & Leaks
COOLING SYSTEM (HEAT/VENT/AC/DEFOG/DEFROST)
-
Radiator condition
-
Pressure Test Radiator Cap and Radiator
-
Cooling Fans, Clutches and Motors
-
Water Pump
-
Air Conditioning System
-
Heating System
-
Cabin Air Filter
-
Coolant Recovery Tank
-
Cabin Air Filter
-
Coolant Condition
FUEL SYSTEM
-
Fuel Pump Noise Normal
-
Fuel Pump Pressure
-
Fuel Filter
-
Fuel Supply System
ELECTRICAL SYSTEM
-
Starter Operation
-
Ignition System
-
Battery
-
Alternator Output
-
Diesel Glow Plug System
TRANSMISSION, TRANSAXLE, DIFFERENTIAL AND TRANSFER CASE
-
Automatic Transmission/Transaxle Oil level and Condition
-
Manual Transmission/Transaxle, Differential and Transfer Case Oil level and Condition
-
Universal Joints, Joints and Joint Boots
-
Transmission Mounts(Not Cracked, Broken or Oil Soaked)
-
Differential/Drive Axle Oil level and Condition
TIRES AND WHEELS
-
Frame Damage
-
Tires and Wheels Match and Are Correct Size
-
Same Tire Size?
-
Tire Tread Depth
-
Normal Tire Wear
-
Rack and Pinion, Linkage and Boots
-
Control Arms, Bushings and Ball Joints
-
Tie Rods and Idler Arm
-
Sway Bars, Linksland Bushings
-
Springs
-
Struts and Shocks
-
Wheel Alignment(Check If Necessary)
-
Power Steering Pump
BRAKES
-
Calipers and Wheel Cylinders
-
Brake Pads and Shoes
-
Rotors and Drums
-
Brake Lines, Hoses and Fittings
-
Parking Brake
-
Master Cylinder and Booster
HYBRID/ELECTRIC VEHICLES
-
Hybrid Cooling System
-
Switchable Powertrain Mount
-
Hybrid Entertainment and Information Display
-
Cargo Management System
-
HighVoltage Thermal System
-
High Voltage Service Disconnect
-
Charging Components Test 1
-
Charging Components Test 2
-
Cell Variation Check
-
DCDC
-
Vehicle Instrument Cluster Lifetime Summary and Trip Resets
-
EVDrive Modes
-
PHEVHeating System Modes
-
BEVHeating System Modes
MODULE SYSTEM TEST
-
Perform SelfTest for all CMDTCs
- Oil Pressure Warning Light
- Tire Pressure Warning Light
- Engine Temperature Warning Light
- Traction Control Alert Light
- Anti-lock Brake System Warning Light
- Engine Warning Light (Check Engine Light)
- Traction Control Malfunction Light
- Battery Alert Light
- Low Fuel Indicator Light
- Automatic Shift Lock or Engine Start Indicator Light
- Seat Belt Reminder Light
- Airbag Warning Light
- Security Indicator Light (Immobilizer)
- Brake Warning Light
- Washer Fluid Indicator Light
- Lane Departure Warning Light
- Transmission Temperature Warning Light
- Dynamic Stability Control
- Hill Descent Control
- Triangle Critical Warning?
- Exhaust Filter | DEF
VEHICLE CONCERN & TROUBLESHOOTING
-
Customer's Concern
-
Sense Identification - Concern 1
- See
- Feel
- Hear
- Smell
- Routine Service or Body Repairs
-
Vehicle Symptoms Area
- Front of Vehicle
- Dash
- Steering Wheel
- Accelerator Pedal
- Brake Pedal
- Clutch Pedal
- Shift Lever/Knob
- Seat
- Rear of Vehicle
- Top of Vehicle
- Floor Pan
- Under Vehicle
- Other (define below
-
How Often ?
- Always
- Daily
- Morning
- Evening
- Conditional
- Weekly
- Monthly
- Intermittent
- Unknown
-
Vehicle Operate Mode ?
- Start Up
- Idle
- Gear Selection
- Light Acceleration
- Moderate Acceleration
- Heavy Acceleration
- Steady Speed
- Deceleration
- Coast Down
- Braking Soft
- Braking Normal
- Braking Hard
- Neutral
- Reverse
- Other (define below)
-
Vehicle Conditions | Surface Condition ?
- Accessories On (define below)
- Windows Open
- 4 x 4
- Hauling
- Towing
- Snow Plowing
- Other (define below)
- Smooth Paved
- Rough Paved
- Bumpy
- Wet
- Irrespective of the surface condition
-
Vehicle Speed (km/h) | Engine Temperature
- 0
- 1 - 20
- 20 - 40
- 40 - 60
- 60 - 80
- 80 - 100
- 100 +
- Cold
- Normal
- Hot (Operating Temp.)
-
When Vehicle Is ?
- Turning Left
- Turning Right
- Over Bumps
- Up Hills
- Down Hills
- Upshifting
- Downshifting
- Parked
- In Traffic
-
Ambient Condition
- (–_______° to –21°C)
- Below Freezing (–20° to –5°C)
- Below Freezing (–5° to –0°C)
- Temp–1° to 10°C
- Temp–11° to 20°C
- Temp–21° to 30°C
- Temp–31°C+
- Sunny
- Dry
- Windy
- Wet/Humid
- Rain
- Snow
- Ice
- Other (Define Below)
-
Sense Identification - Concern 2
- See
- Feel
- Hear
- Smell
- Routine Service or Body Repairs
-
Vehicle Symptoms Area
- Front of Vehicle
- Dash
- Steering Wheel
- Accelerator Pedal
- Brake Pedal
- Clutch Pedal
- Shift Lever/Knob
- Seat
- Rear of Vehicle
- Top of Vehicle
- Floor Pan
- Under Vehicle
- Other (define below
-
How Often ?
- Always
- Daily
- Morning
- Evening
- Conditional
- Weekly
- Monthly
- Intermittent
- Unknown
-
Vehicle Operate Mode ?
- Start Up
- Idle
- Gear Selection
- Light Acceleration
- Moderate Acceleration
- Heavy Acceleration
- Steady Speed
- Deceleration
- Coast Down
- Braking Soft
- Braking Normal
- Braking Hard
- Neutral
- Reverse
- Other (define below)
-
Vehicle Conditions | Surface Condition ?
- Accessories On (define below)
- Windows Open
- 4 x 4
- Hauling
- Towing
- Snow Plowing
- Other (define below)
- Smooth Paved
- Rough Paved
- Bumpy
- Wet
- Irrespective of the surface condition
-
Vehicle Speed (km/h) | Engine Temperature
- 0
- 1 - 20
- 20 - 40
- 40 - 60
- 60 - 80
- 80 - 100
- 100 +
- Cold
- Normal
- Hot (Operating Temp.)
-
When Vehicle Is ?
- Turning Left
- Turning Right
- Over Bumps
- Up Hills
- Down Hills
- Upshifting
- Downshifting
- Parked
- In Traffic
-
Ambient Condition
- (–_______° to –21°C)
- Below Freezing (–20° to –5°C)
- Below Freezing (–5° to –0°C)
- Temp–1° to 10°C
- Temp–11° to 20°C
- Temp–21° to 30°C
- Temp–31°C+
- Sunny
- Dry
- Windy
- Wet/Humid
- Rain
- Snow
- Ice
- Other (Define Below)
-
Sense Identification - Concern 3
- See
- Feel
- Hear
- Smell
- Routine Service or Body Repairs
-
Vehicle Symptoms Area
- Front of Vehicle
- Dash
- Steering Wheel
- Accelerator Pedal
- Brake Pedal
- Clutch Pedal
- Shift Lever/Knob
- Seat
- Rear of Vehicle
- Top of Vehicle
- Floor Pan
- Under Vehicle
- Other (define below
-
How Often ?
- Always
- Daily
- Morning
- Evening
- Conditional
- Weekly
- Monthly
- Intermittent
- Unknown
-
Vehicle Operate Mode ?
- Start Up
- Idle
- Gear Selection
- Light Acceleration
- Moderate Acceleration
- Heavy Acceleration
- Steady Speed
- Deceleration
- Coast Down
- Braking Soft
- Braking Normal
- Braking Hard
- Neutral
- Reverse
- Other (define below)
-
Vehicle Conditions | Surface Condition ?
- Accessories On (define below)
- Windows Open
- 4 x 4
- Hauling
- Towing
- Snow Plowing
- Other (define below)
- Smooth Paved
- Rough Paved
- Bumpy
- Wet
- Irrespective of the surface condition
-
Vehicle Speed (km/h) | Engine Temperature
- 0
- 1 - 20
- 20 - 40
- 40 - 60
- 60 - 80
- 80 - 100
- 100 +
- Cold
- Normal
- Hot (Operating Temp.)
-
When Vehicle Is ?
- Turning Left
- Turning Right
- Over Bumps
- Up Hills
- Down Hills
- Upshifting
- Downshifting
- Parked
- In Traffic
-
Ambient Condition
- (–_______° to –21°C)
- Below Freezing (–20° to –5°C)
- Below Freezing (–5° to –0°C)
- Temp–1° to 10°C
- Temp–11° to 20°C
- Temp–21° to 30°C
- Temp–31°C+
- Sunny
- Dry
- Windy
- Wet/Humid
- Rain
- Snow
- Ice
- Other (Define Below)
-
Sense Identification - Concern 4
- See
- Feel
- Hear
- Smell
- Routine Service or Body Repairs
-
Vehicle Symptoms Area
- Front of Vehicle
- Dash
- Steering Wheel
- Accelerator Pedal
- Brake Pedal
- Clutch Pedal
- Shift Lever/Knob
- Seat
- Rear of Vehicle
- Top of Vehicle
- Floor Pan
- Under Vehicle
- Other (define below
-
How Often ?
- Always
- Daily
- Morning
- Evening
- Conditional
- Weekly
- Monthly
- Intermittent
- Unknown
-
Vehicle Operate Mode ?
- Start Up
- Idle
- Gear Selection
- Light Acceleration
- Moderate Acceleration
- Heavy Acceleration
- Steady Speed
- Deceleration
- Coast Down
- Braking Soft
- Braking Normal
- Braking Hard
- Neutral
- Reverse
- Other (define below)
-
Vehicle Conditions | Surface Condition ?
- Accessories On (define below)
- Windows Open
- 4 x 4
- Hauling
- Towing
- Snow Plowing
- Other (define below)
- Smooth Paved
- Rough Paved
- Bumpy
- Wet
- Irrespective of the surface condition
-
Vehicle Speed (km/h) | Engine Temperature
- 0
- 1 - 20
- 20 - 40
- 40 - 60
- 60 - 80
- 80 - 100
- 100 +
- Cold
- Normal
- Hot (Operating Temp.)
-
When Vehicle Is ?
- Turning Left
- Turning Right
- Over Bumps
- Up Hills
- Down Hills
- Upshifting
- Downshifting
- Parked
- In Traffic
-
Ambient Condition
- (–_______° to –21°C)
- Below Freezing (–20° to –5°C)
- Below Freezing (–5° to –0°C)
- Temp–1° to 10°C
- Temp–11° to 20°C
- Temp–21° to 30°C
- Temp–31°C+
- Sunny
- Dry
- Windy
- Wet/Humid
- Rain
- Snow
- Ice
- Other (Define Below)
-
Sense Identification - Concern 5
- See
- Feel
- Hear
- Smell
- Routine Service or Body Repairs
-
Vehicle Symptoms Area
- Front of Vehicle
- Dash
- Steering Wheel
- Accelerator Pedal
- Brake Pedal
- Clutch Pedal
- Shift Lever/Knob
- Seat
- Rear of Vehicle
- Top of Vehicle
- Floor Pan
- Under Vehicle
- Other (define below
-
How Often ?
- Always
- Daily
- Morning
- Evening
- Conditional
- Weekly
- Monthly
- Intermittent
- Unknown
-
Vehicle Operate Mode ?
- Start Up
- Idle
- Gear Selection
- Light Acceleration
- Moderate Acceleration
- Heavy Acceleration
- Steady Speed
- Deceleration
- Coast Down
- Braking Soft
- Braking Normal
- Braking Hard
- Neutral
- Reverse
- Other (define below)
-
Vehicle Conditions | Surface Condition ?
- Accessories On (define below)
- Windows Open
- 4 x 4
- Hauling
- Towing
- Snow Plowing
- Other (define below)
- Smooth Paved
- Rough Paved
- Bumpy
- Wet
- Irrespective of the surface condition
-
Vehicle Speed (km/h) | Engine Temperature
- 0
- 1 - 20
- 20 - 40
- 40 - 60
- 60 - 80
- 80 - 100
- 100 +
- Cold
- Normal
- Hot (Operating Temp.)
-
When Vehicle Is ?
- Turning Left
- Turning Right
- Over Bumps
- Up Hills
- Down Hills
- Upshifting
- Downshifting
- Parked
- In Traffic
-
Ambient Condition
- (–_______° to –21°C)
- Below Freezing (–20° to –5°C)
- Below Freezing (–5° to –0°C)
- Temp–1° to 10°C
- Temp–11° to 20°C
- Temp–21° to 30°C
- Temp–31°C+
- Sunny
- Dry
- Windy
- Wet/Humid
- Rain
- Snow
- Ice
- Other (Define Below)
-
Other Observation (Outside Customers Concern)
-
Parts Requirements
-
Recommendation on urgent repairs
-
Required parts or repairs on urgent service
-
Recommendation on schedule or discretional repairs
-
Required parts or repairs for discretional or scheduled service
