Title Page
-
members Id
-
Location
-
Prepared by
-
Conducted on
A.G.S.CARCLUB SAFETY INSPECTION & SERVICE
General Information
-
Select vehicle identification type
-
REG
-
Enter Mileage
-
VIN NO.
-
Take photo of vehicle
Body Exterior
-
Panel condition/alignment
- OK
- Needs Repair
- Not Applicable
- Repaired
-
Photo all panels first
-
Paintwork
-
Exterior trim
-
Glass
-
Bumpers and number plates
-
Door locks/Lub all hinges
-
Fuel Filler cover/cap
-
Soft top operation
-
Body damage
-
Corrosion
-
Corrosion Protection
-
Mud Flaps
-
Bonnet catch
-
Bonnet Hinges
-
Body load space condition
Engine Compartment
-
Coolant level/Condition
-
Pressure Test cooling system
-
Coolant Leaks
-
Anti Freeze
-
Radiator/Cap
-
Hoses/Pipes
-
Drive Belts
-
Water Pump
-
Power Steering (oil level)
-
Clutch Fluid
-
Brake Fluid
- Good
- Fair
- Poor
- N/A
-
Replace Brake Fluid to be compliant with MOT rules
-
Advice Member brake fluid may need change
-
Replace Engine Oil and Filter
-
Clean or Replace air filter
- Yes
- No
- N/A
-
only replace the air filter if contaminated
-
Report if spark plugs are due to be changed according to mileage
- Yes
- No
- N/A
-
replace with long life Plugs
-
clean re-gap spark plugs
-
Engine Oil check level
-
External Leaks (Upper engine)
-
Engine Mountings
-
Engine Mountings
-
Carburettor/Fuel Injection
-
Turbo/Supercharger
-
Fuel Pump/Pipes
- OK
- Needs Repair
- Not Applicable
- Repaired
-
replace fuel filter were possible
-
Accelerator Links
-
Cold starting
-
Fast Idle (cold)
-
Noise Level (cold)
-
Excess Fumes/Smoke
Electrical Controls
-
Starting Systems/Ignition lock
-
Battery Condition
-
check battery is secure
-
Battery Voltages
- Pass
- Fail
- N/A
-
record voltage before start
-
record voltage after engine start
-
With engine running record voltage under full load
-
Headlights
-
Sidelights
-
Rear lights
-
Stop Lights
-
Indicators/Hazard lights
-
Reverse/Fog lights
-
Auxiliary Lights
-
Interior/Panel lights
-
Mirrors (electric)
-
Controls/switches
-
Instruments
-
Horn
-
Radio Aerial
-
Heater/Fan controls
-
Air Con operation
-
Windows/sun roof
-
Wipers/washers
-
Headlamp wash/wipe
Interior/Luggage Compartment
-
Steering wheel alignment/Adjustment
-
Seat Upholstery
-
Seat adjustment
-
Seat belts
-
report problem
-
Carpets
-
Door trims panels
-
Door fittings/Operations
-
Door Seals/Hinges
-
Interior sills
-
Headlining/Visors
-
Sun Roof
-
Dash panel (condition)
-
Cigarette Lighter
-
Mirrors (internal)
-
Rear Parcel shelf
-
Boot/Tailgate lock
-
Luggage area trim condition
-
Illumination light
-
Tool kit
-
Soft top (condition)
-
Tonneau cover
Front Suspension/Steering/Underframe
-
Engine underside leakage
-
type of leakage
-
Steering joints/ball joints
-
Steering box/rack
-
Chassis members
-
Power Steering (operation)
-
Wheel hubs/bearings
-
Springs/suspension units
-
Pipes/hoses
-
Dampers (condition/leaks)
-
Gaiters
-
Sub frames mountings
-
Suspension arms/mounts
-
Tie bars/anti roll bars
-
Corrosion Protection
-
Corrosion-floor/chassis
Rear suspension/UnderFrame
-
Springs/suspension bars
-
Anti roll bar
-
Dampers/bushes
-
Suspension arms/fixings
-
Location rods/fixings
-
Bump stops/gaiters
-
Wheel hubs/bearings
-
Pipes/hoses
-
Sub frames/mountings
-
Chassis members
-
Corrosion Protection
-
Corrosion-floor/chassis
Clutch/Transmission
-
Fluid/oil leaks
-
Cables/Adjustments
-
Hydraulic system
-
Linkage (wear)
-
Casings
-
Mountings
-
Drive shaft assembly
-
Universal/sliding Joints
-
Backlash
-
Gaiters
-
Prop shaft(s)
-
Bearings/supports
Exhaust System
-
Manifold
-
Pipes
-
Silencer(s) Catalyst
-
Heat shields/Mountings
-
Joints/couplings
-
System condition
Fuel System
-
Tank
-
Tank Fixings
-
Fuel lines
-
Breather pipes
-
Evidence of leaks
Brakes
-
Master cylinder security
-
Fluid Leaks
-
Servo/power system
-
Flexible hoses
-
Pipes/connections
-
Discs/pads
-
PHOTO REAR D/P
-
PHOTO FRONT
-
PHOTO REAR
-
H/Brake/operation adjustment
-
H/Brake linkage
-
Pedal/linkage
Wheels and Tyres
-
Wheel Rims
-
Wheel Trims
-
Right front tyre
-
PHOTO TYRE Rec T/DP & T/PSI
-
Rec T/DP & T/PSI
-
Rec T/DP & T/PSI
-
Left front tyre
-
PHOTO TYRE Rec T/DP & T/PSI
-
Rec T/DP & T/PSI
-
Rec T/DP & T/PSI
-
Right rear tyre
-
PHOTO TYRE Rec T/DP & T/PSI
-
Rec T/DP & T/PSI
-
Rec T/DP & T/PSI
-
Left rear tyre
-
PHOTO TYRE Rec T/DP & T/PSI
-
Rec T/DP & T/PSI
-
Rec T/DP & T/PSI
-
Spare tyre
Road Test
-
Distance covered up to 10 miles
-
Final drive operation/noise
-
Gearbox operation/noise
-
Engine performance
-
Engine noise
-
Excess smoke
-
Overheating evidence
-
Auto changes/kick down
-
Instruments/controls operation
-
Steering wheel alignment
-
Clutch operation
-
4WD operation
-
Cooling fan operation
-
Steering effort
-
Hot restart
-
Road holding/stability
-
General steering/handling
-
Foot brake operation
-
H/Brake operation
-
Suspension noise
-
Warning Lights
final check
-
Uneven tyre wear
-
Oil leaks
-
Coolant leaks
-
Recheck all wheel nuts are tight
-
top up all fluid levels
Recommendations
-
Enter recommendations here
COMPLETION
-
Full Name and Signature of Inspector
